Page 476 - Manual Oficina XP 1000 14-16

ELECTRICAL

GENERAL INFORMATION

SPECIAL TOOLS ELECTRICAL SERVICE NOTES
Keep the following notes in mind when diagnosing an
PART NUMBER TOOL DESCRIPTION
electrical problem:
PV-43568 Fluke™ 77 Digital Multimeter • All EFI component information and diagnostic testing
procedures are located in the Fuel System chapter.
PV-43526 Connector Test Kit
• Always refer to Digital Wrench when diagnosing and
2870630 Timing Light diagnostic trouble code.
• Refer to wiring diagram for stator and electrical
PU-50338 Battery Hydrometer component resistance specifications.
• When measuring resistance of a component that has a
2460761 Hall Effect Sensor Probe Harness
resistance value under 10 Ohms, remember to
2871745 Static Timing Light Harness subtract meter lead resistance from the reading.
Connect the leads together and record the resistance.
Battery Conductance Analyzer The resistance of the component is equal to tested
PU-50296
(MDX-610P) value minus the lead resistance.
• Become familiar with the operation of your meter. Be
PU-49466 Relay Bypass sure leads are in the proper jack for the test being
performed (i.e. 10A jack for current readings). Refer to
Digital Wrench® (see Chapter 4 –
- DIGITAL WRENCH® OPERATION, the Owner’s Manual included with your meter for more
page ) information.
• Voltage, amperage, and resistance values included in
this manual are obtained with a Fluke™ 77 Digital
Bosch Automotive Service Solutions: 1-800-345-2233
or http://polaris.service-solutions.com/ Multimeter (PV-43568). This meter is used when
diagnosing electrical problems. Readings obtained
with other meters may differ.
TORQUE SPECIFICATIONS • Pay attention to the prefix on the multimeter reading
(K, M, etc.) and the position of the decimal point.
ITEM TORQUE • For resistance readings, isolate the component to be
tested. Disconnect it from the wiring harness or power
Coolant Temperature 17 ft-lb (23 Nm) supply.
Sensor • Most electrical issues are related to damaged wiring.
Fully test wiring before replacing any components.

Starter Mounting 7 ft-lb (10 Nm)
Fasteners UNDER-DASH COMPONENTS
The following switches and components can be
accessed underneath the instrument / dash panel:
Oxygen Sensor 13 ft-lb (18 Nm)
• Speedometer
• AWD Switch
• Headlamp Switch
• 12 Vdc Accessory Power Point
• Ignition Switch
• LED Ambiance Light

11.4 9926816 R06 - 2014-2016 RZR XP 1000 / XP4 1000 Service Manual
© Copyright Polaris Industries Inc.