Page 70 - Manual Oficina Polaris Sportsman 570 2014 a 2016

MAINTENANCE

PERIODIC MAINTENANCE CHART KEY

SYMBOL DESCRIPTION
► Perform these operations more often for vehicles subjected to severe use.
E Emission-related Control System Service (California)
Failure to conduct this maintenance will not void the emissions warranty but may affect
emissions
■ Have an authorized POLARIS dealer perform these services.

SEVERE USE ITEM: Severe Use is defined as frequent vehicle immersion in mud, water or sand, racing or race-style
high rpm use, prolonged low speed - heavy load operation or extended idle. More preventative maintenance is
required under these conditions. Fluid changes, cable and chassis lubrication are required more frequently. For engine
oil, short trip cold weather riding also constitutes severe use. Pay special attention to oil level. A rising oil level in cold
weather can indicate contaminants collecting in the oil sump or crankcase. Change oil immediately and monitor level. If
oil level begins to rise, discontinue use and determine cause.
NOTE
Inspection may reveal the need for replacement parts. Always use genuine Polaris parts.

WARNING
Improperly performing the procedures marked with a ■ could result in component failure and lead to serious injury or
death. Have an authorized Polaris dealer perform these services.

PERIODIC MAINTENANCE CHART

Periodic Maintenance Chart
MAINTENANCE INTERVAL
(WHICHEVER COMES FIRST)

ITEM HRS CALENDAR MILES (KM) REMARKS
▶ - Weekly - Inspect; replace as needed
E Air filter, main element
Drain water as needed, check often
Recoil housing - Weekly -
if operating in wet conditions
▶ Brake pad wear Monthly 100 (160) Inspect periodically
■ 10 H
Battery 20 H Monthly 200 (320) Check terminals; clean; test
▶ Engine breather Monthly 250 (400) Inspect; replace if necessary
E filter (if equipped) 25 H
Inspect; Cycle the Key to pressurize the
Fuel System 25 H Monthly — fuel pump; check lines and fittings for
leaks and abrasion.
▶ Engine oil change Monthly 250 (400) Perform a break-in oil and filter change
E (break-in) 25 H
Initial fluid level inspection; Change
▶ Demand drive fluid 25 H Monthly 250 (400)
yearly*
▶ Rear gearcase oil 25 H Monthly 250 (400) Initial fluid level inspection; Change yearly
▶ Transmission fluid 25 H Monthly 250 (400) Initial fluid level inspection; Change yearly
Lubricate all grease fittings, pivots,
▶ General lubrication 50 H 3 M 500 (800)
cables, etc.
■ Throttle Cable/ 500 (800) Inspect; adjust; lubricate; replace if
E TRS Switch 50 H 6 M necessary

2.4 9926803 R06 - 2014-2016 Sportsman 325 / ETX / 450 HO / 570 Service Manual
© Copyright Polaris Industries Inc.