Page 716 - Manual Oficina Polaris Sportsman 570 2014 a 2016

ELECTRICAL

LOW MAINTENANCE BATTERY CHARGING LOW MAINTENANCE BATTERY OFF-
PROCEDURE SEASON STORAGE
1. Remove the battery from the ATV to prevent damage Battery voltage should be checked with a digital
from leaking or spilled acid during charging (see multitester. Readings of 12.8 volts or less require further
Battery Removal). battery testing and charging. See charts and Load Test.
2. Charge the battery with a variable rate charging • Remove the battery from the machine and wash the
output. Charge as needed to raise the specific case and battery tray with a mild solution of baking
gravity to 1.270 or greater. soda and water. Rinse with lots of fresh water after
cleaning.
3. Install the battery (see Battery Installation).
• Using a wire brush or knife, remove any corrosion from
the cables and terminals.
• Make sure that the electrolyte is at the proper level.
• Charge at a rate no greater than 1/10 of the battery's
amp/hr capacity until the electrolyte's specific gravity
reaches 1.270 or greater.
• Store the battery either in the machine with the cables
disconnected, or store in a cool place.
NOTE

Stored batteries lose their charge at the rate of 1% per
day. Recharge to full capacity every 30 to 60 days
during a non-use period. If the battery is stored during
the winter months, electrolyte will freeze at higher
temperatures as the battery discharges. The chart
below indicates freezing points by specific gravity.

SPECIFIC GRAVITY OF
ELECTROLYTE FREEZING POINT
1.265 -75° F
1.225 -35° F
1.200 -17° F
1.150 +5° F
1.100 +18° F
1.050 +27° F

11.54 9926803 R06 - 2014-2016 Sportsman 325 / ETX / 450 HO / 570 Service Manual
© Copyright Polaris Industries Inc.