Page 495 - Manual Oficina XP 1000 14-16

P. 495

ELECTRICAL

BATTERY

BATTERY SPECIFICATIONS GENERAL BATTERY INFORMATION

Polaris / Johnson Controls 575 WARNING
Type
Sealed - Maintenance Free
CALIFORNIA PROPOSITION 65 WARNING:Batteries,
Voltage 12 Vdc battery posts, terminals and related accessories contain
lead and lead compounds, and other chemicals known
Nominal Capacity to the State of California to cause cancer and birth
@ 10 HR Rate 30 AH
defects or other reproductive harm. WASH HANDS
CCA 575 AFTER HANDLING.
Nominal Open
Circuit Voltage 12.8 Vdc or more. WARNING

Recommended 1.8A @ 5-10 HR or 6.0A @ 1 Battery electrolyte is poisonous. It contains acid!
Charging Rate HR Serious burns can result from contact with the skin,
eyes, or clothing.
NOTE ANTIDOTE:

Never attempt to open the battery. If the seal is broken, External: Flush with water.
the battery will be ruined and will fail within a few Internal: Drink large quantities of water or milk. Follow
weeks. with milk of magnesia, beaten egg, or vegetable oil. Call
a physician immediately.
Eyes: Flush with water for 15 minutes and get prompt
medical attention.

Batteries produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
batteries.

Keep out of reach of children.

1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to
be recharged (see Chapter 11 – Charging Procedure
, page 11.25).
To service a Maintenance Free battery:
3. Remove battery from the vehicle (see Battery
Removal, page 2.40).
4. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to OCV table (see OCV - Open 11
Circuit Voltage Test, page 11.24).
5. Charge the battery as recommended (see –
Charging Procedure , page 11.25).

490 491 492 493 494 495 496 497 498 499 500