Page 219 - Manual Oficina Polaris RZR XP 1000 17-18

FUEL SYSTEM

5. Place the fuel line back over the fitting and slide the 3. While holding a shop towel over the fuel line
green connector locking mechanism back into place. connectors, disconnect the fuel supply line q from
Verify the connector tabs snap back into place. the pump (see Chapter 2 – Fuel Linespage 2.42 for
specific removal procedure).
6. Be sure fuel line is routed and retained properly.

4

NOTE
e Retaining Clip r Zip Tie
A small amount of fuel may come out of the fuel lines or
pump fitting. Properly drain fuel into a suitable
FUEL TANK REMOVAL container.

NOTE 4. Disconnect the fuel pump electrical harness w.
Syphon as much fuel from the tank as possible before 5. Remove the push rivets and Torx screws retaining
attempting to remove it from the vehicle. the right-hand rocker panel using the multi-function
pliers and a T40 Torx driver. Remove the rocker
panel r from the vehicle.
WARNING
Always wear safety goggles when working with high
pressure or flammable fluids. Failure to do so could
result in serious injury or complications.

1. Remove the driver and passenger seats.
2. Disconnect the negative and positive battery cables
from the battery, located under the driver’s seat.
Remove the bolt retaining the battery bracket and
remove the battery from the vehicle.

9928492 R06 - 2017-2018 RZR XP 1000 / XP4 1000 Service Manual 4.25
© Copyright Polaris Industries Inc.